Cornelius SID650W/80-BC Betreibershandbuch PDF herunterladen (Seite 35)

3291704

HARVEST TIME ADJUSTMENT

W ARNING: Disconnect electrical power to the unit before servicing the timer in the

electrical box.

1. Disconnect power to ice maker.

2. Remove upper front panel and electrical control box cover.

3. Place the “Stop/Run”switch in the “Stop”position.

4. Using Figure 9 a s a guide, set the timer cam tabs as follows, starting with cam wheel No.1 (all cam tab

positions are in relation to No.1 left cam tab).

NOTE: Timer cam wheels can be manually rotated only i n the normal direction of rotation-downward as

viewed from the front of the unit.

A. “Manually”adjust the cam t abs by using each “click”as the cam tab is rotat ed, as equivalent to .75

seconds.

B. Set up cam wheel No.1 with the left and right cam tabs back-to-back as shown in Figure 9A.

C. Adjust the cam t abs on wheels No. 2 through No. 5 in sequence as shown on the chart. Rotate t h e

cam wheels manually downward to set each wheel.

D. After the cam tabs are manually set, reconnect power t o the ice maker.

E. Rotate the cam wheels slightly to activate the timer motor (No. 1 t ell-tale down).

F. Using a stop watch, time t he cam switch t ell-tales. Adjust the cam t abs as necessary for the required

cycle times.

MANUAL FILLING

In t he event that the ice maker is not functioning, the hopper m ay be manually filled with ice.

1. Open the hinged service door.

2. Place the “Stop/ Run”switch in the “Stop”position.

W ARNING: Electrical power is on to the agitator motor and the gate solenoid. Avoid

contact with these components.

3. Remove the ice drop and storage hopper covers.

4. Fill hopper with ice and replace covers. Unit is now ready for dispensing.

CAUTION: Do not use crushed or flaked ice. Use of bagged ice, which has frozen into large

chunks, can void warranty

. The agitator is not designed to be an ice crusher. Use of large

chunks of ice which “jam up” inside the hopper will cause failure of the agitator motor and

damage the hopper. If bagged ice is used, it must be carefully

and completely broken into small,

cube-size pieces before filling i nto the storage hopper. Do not allow foreign material to enter the

ice storage hopper.

1 2 ... 30 31 32 33 34 35 36 37 38 39 40

Keine Kommentare

Cornelius SID650W/80-BC Betreibershandbuch Seite 35