CHILLER (“CH” SERIES)Operator’s ManualModels: CH 1001-ACH 1501-ACH 1502-ACH 1503-APRINTED IN U.S.AIMI CORNELIUS INC; 1999--2000IMI CORNELIUS REMCOR I
8620914301THIS PAGE LEFT BLANK INTENTIONALLY
9620914301TROUBLESHOOTINGW ARNING: Disconnect electrical power to the Chiller to prevent personal injury beforeattempting any internal maintenance. On
10620914301TROUBLE REMEDYPROBABLE CAUSECHILLER DOES NOTOPERATE, BUT POWERLIGHT IS “ON” AND REDSAFETY LIGHT IS “ON”.A. Unit is operating under highpres
11620914301FIGURE 6. PROCESS LIQUID FLOW SCHEMATICPROCESSSUPPLYPROCESSRETURNRESERVOIRAUTOBYPASSPUMPEVAPORATORPROCESS CONTROLTEMPERATURE SENSORLOWTEMPS
12620914301FIGURE 8. WIRING DIAGRAM (CH1001--A, CH1501--A, 230/1/60)WIRECOLOR CODINGB = BLACKBL = BLUER=REDOR = ORANGEY = YELLOWG = GREENBR = BROWNV =
13620914301RBL1L2TRANSFMRM1M2COMPRESSORPUMPBLCALWAM1M3M2SSRFU11RPB2ORCTYSVHG67R6W6W5VJ4VHP3YLT9R5V2RRFS2OR2R8RRFLLLSSSRRR12131415+--5VDCSSR RATING5 FL
14620914301FIGURE 10. WIRING DIAGRAM CH1501 230/3/60, 460/3/60 FLOW SWITCH HIGH TEMP.INTERLOCK, LOW LEVEL ALARMLEGENDM1 -- COMPRESSOR CONTACTORM2 -- P
156209143013215224218192024251512141371617610239811126FIGURE 11. CABINET SECTION EXPLODED VIEW
16620914301CABINET SECTIONItemNo.Part No. Name1 620028005 Base, Pump/Tank2 620028001 Panel, Front3 31036 Electrical Junction Box (DX Unit)15696 Electr
17620914301234567859108111FIG URE 12. ELECT RI CAL BOX ASS’Y EXPLODED VIEWItemNo.Part No. Name1 620028012 Enclosure, Electrical Box2 32829R Transforme
i620914301TABLE OF CONTENTSPageGENERAL INFORMATION 1...INTRODUCTION 1...
18620914301WARRANTYIMI Cornelius Inc. warrants t hat all equipment and parts are free from defects in material and workmanship un-der normal use and s
17620914301THIS PAGE LEFT BLANK INTENTIONALLY
IMI CORNELIUS INC.CORPORATE HEADQUARTERS:One Cornelius PlaceAnoka, Minnesota 55303-6234(763) 421-6120(800) 238-3600
1620914301GENERAL INFORMATIONINTRODUCTIONThe REMCOR ”CH” Series Recirculating Liquid Chiller is designed to provide an accurate, reliable, and user--f
2620914301When servicing a REMCOR Chiller, it is important to note the information contained on the data plate located inthe upper rear of the Unit.If
3620914301Electrical Co n n ectio n s(see Figure 2 and 8)All wiring must conform to the National Electric Code and any applicable local codes. The Chi
46209143012. CONTROL POWER SWITCH/LIGHT (see Figure 3)A lighted ON/OFF push button switch is used to switch power to the 24 VAC control circuit. The s
5620914301that the shaft is rotating in the direction of the arrow indicated on the pump housing. If the rotation is incorrect,reverse two of the thre
6620914301TEMPERATURE CONTROLLER OPERATION(see Figure 4)During normal operation, the process temperature will be displayed on the Controller. The foll
7620914301CondenserOn air--cooled Chillers, the CONDENSER FINS should be cleaned by blowing compressed air through the con-denser from the fan side. D
Kommentare zu diesen Handbüchern