Cornelius 322 Spezifikationen PDF herunterladen (Seite 14)

Xtreme Ice Training Manual

TP00952

October 17, 2005 9

Preventative Maintenance Sequence

The installation is not complete until you are sure the owner-operator understands the cuber operation

and his or her responsibility of preventative maintenance.

Does the owner-operator know:

Location of electrical disconnect switch and water shut-off valves?

2. How to start and/or shut down the product, clean and sanitize it?

3. Bin full operation and reset operation of high pressure cutout (water-cooled and remote

products and 500 series (Air Cooled)?

4. How to clean the condenser and fan blade?

5. Whom to call for product information and/or service?

NOTE: CONDENSER SENSOR USED ONLY ON A/C UNITS. 1.8K ohm RESISTER USED ONLY ON

W/C & R/C UNITS.

1 2 ... 9 10 11 12 13 14 15 16 17 18 19 ... 59 60

Service / Training Manual 1
TABLE OF CONTENTS 3
PRODUCT PREVIEW 6
MODEL AND SERIAL LOCATION 7
October 17, 2005 3 8
NA= Not applicable 9
TECHNICAL SPECIFICATIONS 10
INSTALLATION INSTRUCTIONS 11
DISPENSER INSTALLATION 12
PLUMBING CONNECTIONS 13
ELECTRICAL 13
INSTALLATION CHECK POINTS 13
START UP AND CHECK OUT 13
October 17, 2005 9 14
Xtreme Ice Training Manual 14
CLEANING PROCEDURES 15
PREP – CLEANING PROCEDURE 16
October 17, 2005 17
OPERATIONS 18
START UP SEQUENCE (PRIMARY) 19
SECONDARY START UP 19
DUMP CYCLE 19
WATER FILL CYCLE 19
FREEZE CYCLE 20
HARVEST CYCLE 20
FAN CONTROL 20
ADJUSTING BRIDGE THICKNESS 21
TOTAL ICE CAPACITY 21
ICE PRODUCTION CHECK 21
FIGURE 10 22
LED INDICATORS 23
Curtain Open 24
Prechill Mode 24
Ice-Making Mode 24
Harvest Mode 24
HARVEST BUTTON 25
CLEAN CYCLE 25
SAFETY (OLD SOFTWARE) 26
WATER FILL TIME OUT 27
MAXIMUM FREEZE TIME OUT 27
HARVEST TIME OUT 28
BIN FULL DELAY 28
HIGH CONDENSER TEMPERATURE 28
OPEN CONDENSER THERMISTOR 29
FAILED WATER TEMPERATURE 29
OPEN WATER THERMISTOR 29
SAFETY (NEW SOFTWARE) 30
FAILED HARVEST SHUTDOWN 31
October 17, 2005 27 32
Possible Causes 33
RESET OPERATION 34
VOLTAGE CHECKS 34
STACKING CABLE 34
CONDENSER FAN CYCLING CONTROL 35
THERMOSTATIC EXPANSION VALVES 35
WATER REGULATING VALVE 36
SERVICE STEM VALVES 36
MOISTURE CONTAMINATION 37
COMPRESSOR CONTACTOR 37
Potential – 38
Current – 38
Capacitors 38
LEAK DETECTION 39
SELF-CONTAINED PRODUCTS 40
HIGH PRESSURE SAFETY SWITCH 41
COMPRESSOR RUN-ON 41
TROUBLESHOOTING 42
October 17, 2005 39 44
FIGURE 16 46
FIGURE 17 47
XTREME ICE – KITS 48
631500074 49
FIGURE 19 50
SEE DETAIL 51
DETAIL A 51
SCALE 1:2 51
8–32 HEX 51
REMOTE CONDENSERS 52
REMOTE CONDENSER LOCATION 54
October 17, 2005 51 56
FIGURE 30 58
One Cornelius Place 60
Anoka, Minnesota 55303-6234 60
(763) 421-6120 60
(800) 238-3600 60

Kommentare zu diesen Handbüchern

Keine Kommentare

Cornelius 322 Spezifikationen Seite 14

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Eiswürfelmacher Cornelius 322