Cornelius I Series Spezifikationen PDF herunterladen (Seite 13)

TP00952

November 26, 20018

Preventative Maintenance Sequence

The installation is not complete until you are sure the owner-operator understands the cuber operation

and his or her responsibility of preventative maintenance.

Does the owner-operator know:

Location of electrical disconnect switch and water shut-off valves?

2. How to start and/or shut down the product, clean and sanitize it?

Bin full operation and reset operation of high pressure cutout (water-cooled and remote

products and 500 and 600 series (Air Cooled)?

4. How to clean the condenser and fan blade?

Whom to call for product information and/or service?

NOTE: CONDENSER SENSOR USED ONLY ON A/C UNITS. 1.8K ohm RESISTER USED ONLY ON

W/C & R/C UNITS.

1 2 ... 8 9 10 11 12 13 14 15 16 17 18 ... 53 54

Service / Training Manual 1
TABLE OF CONTENTS 3
PRODUCT PREVIEW 6
MODEL AND SERIAL LOCATION 7
SPECIFICATIONS 8
TECHNICAL SPECIFICATIONS 9
INSTALLATION INSTRUCTIONS 10
DISPENSER INSTALLATION 11
PLUMBING CONNECTIONS 12
ELECTRICAL 12
INSTALLATION CHECK POINTS 12
START UP AND CHECK OUT 12
November 26, 20018 13
CLEANING PROCEDURES 14
PREP – CLEANING PROCEDURE 15
November 26, 2001 11 16
OPERATIONS 17
START UP SEQUENCE (PRIMARY) 18
SECONDARY START UP 18
DUMP CYCLE 18
WATER FILL CYCLE 18
PRECHILL CYCLE 18
FREEZE CYCLE 19
HARVEST CYCLE 19
FAN CONTROL 19
CALIBRATION MODE 19
ADJUSTING BRIDGE THICKNESS 20
TOTAL ICE CAPACITY 20
ICE PRODUCTION CHECK 20
FIGURE 10 21
LED INDICATORS 22
HARVEST BUTTON 23
CLEAN CYCLE 24
SAFETY FEATURES 25
WATER FILL TIME OUT 25
MAXIMUM FREEZE TIME OUT 26
HARVEST TIME OUT 26
BIN FULL DELAY 27
HIGH CONDENSER TEMPERATURE 27
OPEN CONDENSER THERMISTOR 27
RESET OPERATION 28
VOLTAGE CHECKS 28
STACKING CABLE 28
CONDENSER FAN CYCLING CONTROL 29
THERMOSTATIC EXPANSION VALVES 29
WATER REGULATING VALVE 30
SERVICE STEM VALVES 30
MOISTURE CONTAMINATION 31
COMPRESSOR CONTACTOR 31
Potential – 32
Current – 32
Capacitors 32
LEAK DETECTION 33
SELF-CONTAINED PRODUCTS 34
HIGH PRESSURE SAFETY SWITCH 35
COMPRESSOR RUN-ON 35
TROUBLESHOOTING 36
November 26, 200132 37
November 26, 2001 33 38
November 26, 200134 39
FIGURE 16 40
FIGURE 17 41
XTREME ICE – KITS 42
631500074 43
FIGURE 19 44
SEE DETAIL 45
DETAIL A 45
SCALE 1:2 45
8–32 HEX 45
REMOTE CONDENSERS 46
REMOTE CONDENSER LOCATION 48
November 26, 2001 45 50
November 26, 200146 51
FIGURE 30 52
November 26, 200148 53
One Cornelius Place 54
Anoka, Minnesota 55303-6234 54
(763) 421-6120 54
(800) 238-3600 54

Kommentare zu diesen Handbüchern

Keine Kommentare

Cornelius I Series Spezifikationen Seite 13

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Eiswürfelmacher Cornelius I Series