Cornelius I Series Spezifikationen Seite 26
- Seite / 54
- Inhaltsverzeichnis
- FEHLERBEHEBUNG
- LESEZEICHEN
Bewertet. / 5. Basierend auf Kundenbewertungen
TP00952
November 26, 2001 21
MAXIMUM FREEZE TIME OUT
1. At the beginning of the prechill cycle, the microprocessor starts a timer.
2. If the timer reaches 50 minutes before a harvest cycle can be initiated, the machine enters a delay
sequence.
3. After each delay, the machine restarts at the secondary start up.
4. The delay sequence continues as follows:
S Freeze try, 30 min delay, freeze try, 30 min delay, freeze try, 2 hr delay,
S Freeze try, 30 min delay, freeze try, 30 min delay, freeze try, 2 hr delay,
S Freeze try, 30 min delay, freeze try, 30 min delay, freeze try, 2 hr delay,
S Freeze try, 30 min delay, freeze try, 30 min delay, freeze try, 2 hr delay,
S Freeze try, 30 min delay, freeze try, 30 min delay, freeze try, shut down.
5. During the delay times, the DELAY LED flashes 4 times at 4 second intervals.
6. Once the Machine reaches shut down position all out puts turn off.
7. At the shut down time, the ERROR LED flashes 4 times at 4 second intervals.
8. The machine will not run until the power is cycled.
9. The delay sequence resets after each successful harvest.
Possible Causes
1. Water pump failure
2. Low refrigerant charge
3. Leak in refrigerant lines
4. Compressor failure
5. Hot gas valve leaking
6. Dirty evaporator
HARVEST TIME OUT
1. If the microprocessor does not recognize all proximity switch circuits opening 4 minutes after the hot
gas valve opens during the harvest cycle, the machine enters a delay sequence.
2. After each delay, the machine restarts at the secondary start up.
3. The delay sequence continues as follows:
S Harvest try, 30 min delay, harvest try, 30 min delay, harvest try, 2 hr delay.
S Harvest try, 30 min delay, harvest try, 30 min delay, harvest try, 2 hr delay.
S Harvest try, 30 min delay, harvest try, 30 min delay, harvest try, 2 hr delay.
S Harvest try, 30 min delay, harvest try, 30 min delay, harvest try, 2 hr delay.
S Harvest try, 30 min delay, harvest try, 30 min delay, harvest try, shut down.
4. During the delay times, the DELAY LED flashes 3 times at 4 second intervals.
5. Once the machine reaches shut down position all out puts turn off.
6. At the shut down time, the ERROR LED flashes 3 times at 4 second intervals.
7. The machine will not run until the power is cycled.
8. The delay sequence resets after each successful harvest.
Possible Causes
1. Hot gas valve failure
2. Low refrigerant charge
3. Prox. Switch
4. Compressor failure
- Service / Training Manual 1
- TABLE OF CONTENTS 3
- PRODUCT PREVIEW 6
- MODEL AND SERIAL LOCATION 7
- SPECIFICATIONS 8
- TECHNICAL SPECIFICATIONS 9
- INSTALLATION INSTRUCTIONS 10
- DISPENSER INSTALLATION 11
- PLUMBING CONNECTIONS 12
- ELECTRICAL 12
- INSTALLATION CHECK POINTS 12
- START UP AND CHECK OUT 12
- November 26, 20018 13
- CLEANING PROCEDURES 14
- PREP – CLEANING PROCEDURE 15
- November 26, 2001 11 16
- OPERATIONS 17
- START UP SEQUENCE (PRIMARY) 18
- SECONDARY START UP 18
- DUMP CYCLE 18
- WATER FILL CYCLE 18
- PRECHILL CYCLE 18
- FREEZE CYCLE 19
- HARVEST CYCLE 19
- FAN CONTROL 19
- CALIBRATION MODE 19
- ADJUSTING BRIDGE THICKNESS 20
- TOTAL ICE CAPACITY 20
- ICE PRODUCTION CHECK 20
- FIGURE 10 21
- LED INDICATORS 22
- HARVEST BUTTON 23
- CLEAN CYCLE 24
- SAFETY FEATURES 25
- WATER FILL TIME OUT 25
- MAXIMUM FREEZE TIME OUT 26
- HARVEST TIME OUT 26
- BIN FULL DELAY 27
- HIGH CONDENSER TEMPERATURE 27
- OPEN CONDENSER THERMISTOR 27
- RESET OPERATION 28
- VOLTAGE CHECKS 28
- STACKING CABLE 28
- CONDENSER FAN CYCLING CONTROL 29
- THERMOSTATIC EXPANSION VALVES 29
- WATER REGULATING VALVE 30
- SERVICE STEM VALVES 30
- MOISTURE CONTAMINATION 31
- COMPRESSOR CONTACTOR 31
- Potential – 32
- Current – 32
- Capacitors 32
- LEAK DETECTION 33
- SELF-CONTAINED PRODUCTS 34
- HIGH PRESSURE SAFETY SWITCH 35
- COMPRESSOR RUN-ON 35
- TROUBLESHOOTING 36
- November 26, 200132 37
- November 26, 2001 33 38
- November 26, 200134 39
- FIGURE 16 40
- FIGURE 17 41
- XTREME ICE – KITS 42
- 631500074 43
- FIGURE 19 44
- SEE DETAIL 45
- DETAIL A 45
- SCALE 1:2 45
- 8–32 HEX 45
- REMOTE CONDENSERS 46
- REMOTE CONDENSER LOCATION 48
- November 26, 2001 45 50
- November 26, 200146 51
- FIGURE 30 52
- November 26, 200148 53
- One Cornelius Place 54
- Anoka, Minnesota 55303-6234 54
- (763) 421-6120 54
- (800) 238-3600 54
Verwandte Produkte und Handbücher für Eiswürfelmacher Cornelius I Series
(22 Seiten)© 2020, manymanuals.de. Alle Rechte vorbehalten. | 1.776 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Kommentare zu diesen Handbüchern